The URL can be used to link to this page

Home My WebLink About3617 S College Ave - Special Inspections/Field Verification - 12/21/2017Lawrence H. Finn & Associates, Inc. 55 S. Elm Ave., Suite 220 – Eaton, CO 80615 Phone (970) 454-5351 – Fax (970) 454-5391 CERTIFIED TEST, ADJUST, AND BALANCE REPORT DATE 12/21/17 PROJECT Fort Collins Dental 3617 South College Avenue Fort Collins, CO ***Final Report*** ARCHITECT Architectural Solutions, Inc. 1308 West Pikes Peak Avenue Colorado Springs, CO ENGINEER Aaron Ivan Springfield CONTRACTOR Poudre Valley Air 2416 Donella Court Fort Collins, CO Lawrence H. Finn & Associates, Inc. 55 S. Elm Ave, Suite 220 – Eaton, CO 80615 Phone (970) 454-5351 – Fax (970) 454-5391 PROJECT: Fort Collins Dental ADDRESS: 3617 South College Avenue Fort Collins, CO The data presented in this report is an exact record of the system performance and was obtained in accordance with NEBB Standard Procedures. Any variances from design quantities which exceed NEBB tolerances are noted throughout the report. The air distribution systems have been tested & balanced and final adjustments have been made in accordance with NEBB “Procedural Standards for Testing, Adjusting & Balancing of Environmental Systems” and the project specifications. NEBB TAB FIRM: Lawrence H. Finn & Associates, Inc. REG. NO.: 2389 CERTIFIED BY: David C. Reichel DATE:12/21/17 The hydronic distribution systems have been tested & balanced and final adjustments have been made in accordance with NEBB “Procedural Standards for Testing, Adjusting & Balancing of Environmental Systems” and the project specifications. NEBB TAB FIRM: Lawrence H. Finn & Associates, Inc. REG. NO.: 2389 CERTIFIED BY: David C. Reichel DATE:12/21/17 SUBMITTED & CERTIFIED BY NEBB TAB FIRM: Lawrence H. Finn & Associates, Inc. TAB SUPERVISOR: David C. Reichel REG. NO.: 2389 SIGNATURE: DATE: 12/21/17 CERTIFICATION EXPIRATION DATE: 3/31/2018 Table Of Contents PROJECT: LOCATION: Ft Collins Dental Interior Remodel Ft Collins, CO DATE: CONTACT: AUTHOR: 12/21/2017 Keith Finn Joe Marshall Table Of Contents 1 Instrument Calibration Report.pdf............................................................................................................................ 1 2 Abbreviation Report.pdf........................................................................................................................................... 3 3 Roof Top Unit........................................................................................................................................................... 4 3.1 RTU-3................................................................................................................................................................. 4 3.2 RTU-3/Supply..................................................................................................................................................... 5 4 Fan Unit.................................................................................................................................................................... 6 4.1 EF-1.................................................................................................................................................................... 6 4.2 EF-2.................................................................................................................................................................... 6 4.3 EF-3.................................................................................................................................................................... 7 4.4 EF-4.................................................................................................................................................................... 7 4.5 EF-5.................................................................................................................................................................... 8 5 Prints.pdf.................................................................................................................................................................. 9 L.H. Finn and Associates Final Report Manufacturer Model Serial Application Cal. Date Alnor HM-680 70552109 Hydronic Press. & Diff. Press. 1/16/2014 Alnor HM-680 70750150 Hydronic Press. & Diff. Press. 12/14/2015 Alnor HM-680 70838501 Hydronic Press. & Diff. Press. 11/30/2015 Alnor HM-680 71021246 Hydronic Press. & Diff. Press. 4/5/2016 Alnor HM-680 71043011 Hydronic Press. & Diff. Press. 6/10/2015 Alnor HM-680 91139097 Hydronic Press. & Diff. Press. 7/7/2017 Cooper SH66A 92711016 Temperature Measurement 10/9/2017 Extech 461895 Q394479 Rotation Measurement 4/17/2017 Extech 461895 Q083481 Rotation Measurement 1/9/2014 Extech 461895 Q247569 Rotation Measurement 3/8/2016 Extech 461895 L268576 Rotation Measurement 3/8/2016 Extech 461895 Q331990 Rotation Measurement 11/4/2014 Extech 461895 Q477125 Rotation Measurement 9/25/2015 Extech 461895 Q477126 Rotation Measurement 4/5/2016 Extech 461895 Q527632 Rotation Measurement 10/3/2017 Extech 461895 Q590099 Rotation Measurement 4/17/2017 Extech RH390 9099221 Temperature / Humidity 4/9/2015 Fluke 335 96960004 Electrical Measurement 11/5/2015 Fluke 336 97110539R Electrical Measurement 4/5/2016 Fluke 336 97110538R Electrical Measurement 9/29/2015 Fluke 335 92008180 Electrical Measurement 11/4/2014 Fluke 335 12990071 Electrical Measurement 3/4/2016 Fluke 374 15460133 Electrical Measurement 4/18/2014 Fluke 374 20030351 Electrical Measurement 10/3/2017 Fluke 374 20030354 Electrical Measurement 4/17/2017 TSI 8322 55100720 Air Velocity Measurement 10/4/2017 Shortridge ADM-860C M05789 Digital Manometer 11/25/2015 Shortridge ADM-860C M06821 Digital Manometer 4/18/2017 Shortridge ADM-860C M07352 Digital Manometer 6/6/2016 Shortridge ADM-860C M09123 Digital Manometer 4/18/2016 Shortridge ADM-860C M09347 Digital Manometer 9/26/2015 Shortridge ADM-860C M10144 Digital Manometer 4/14/2017 Shortridge ADM-860C M10371 Digital Manometer 11/5/2015 Shortridge ADM-860C M11448 Digital Manometer 4/14/2017 Shortridge HDM-300 W02060 Hydronic Press. & Diff. Press. 10/5/2015 Shortridge HDM-250 W09198 Hydronic Press. & Diff. Press. 4/18/2017 Shortridge HDM-250 W98020 Hydronic Press. & Diff. Press. 4/8/2015 REMARKS: Not all equipment shown was used on this project. Project: Fort Collins Dental Lawrence H. Finn & Associates, Inc. 55 S. Elm Ave, Suite 220 - Eaton, CO 80615 Phone (970) 454-5351 - Fax (970) 454-5391 INSTRUMENT CALIBRATION REPORT Page 1 of 12 Evergreen Telemetry S-PVF-1 1500177 Pressure Velocity Module 10/3/2017 Evergreen Telemetry S-PVF-1 1500176 Pressure Velocity Module 10/3/2017 Evergreen Telemetry S-PVF-1 1700352 Pressure Velocity Module 9/22/2017 Evergreen Telemetry S-PVF-1 1600314 Pressure Velocity Module 9/27/2016 Evergreen Telemetry S-PVF-1 1600319 Pressure Velocity Module 9/28/2016 Evergreen Telemetry S-PVF-1 1600317 Pressure Velocity Module 9/29/2016 Evergreen Telemetry S-PVF-1 1600323 Pressure Velocity Module 9/30/2016 Evergreen Telemetry S-PVF-1 1600324 Pressure Velocity Module 10/1/2016 Evergreen Telemetry S-PVF-1 1600321 Pressure Velocity Module 10/2/2016 Evergreen Telemetry S-PVF-1 1600322 Pressure Velocity Module 10/3/2016 Evergreen Telemetry S-PVF-1 1700213 Pressure Velocity Module 5/12/2017 Evergreen Telemetry S-PVF-1 1700214 Pressure Velocity Module 5/12/2017 Evergreen Telemetry S-PVF-1 1700215 Pressure Velocity Module 5/12/2017 Evergreen Telemetry S-PVF-1 1700216 Pressure Velocity Module 5/12/2017 Evergreen Telemetry S-PVF-1 1700217 Pressure Velocity Module 5/12/2017 Evergreen Telemetry S-PVF-1 1700218 Pressure Velocity Module 5/12/2017 Evergreen Telemetry RM-T-1 1700269 Radio Module 5/17/2017 Evergreen Telemetry RM-T-1 1600236 Radio Module 10/10/2016 Evergreen Telemetry RM-T-1 1600235 Radio Module 10/12/2016 Evergreen Telemetry RM-T-1 1600233 Radio Module 10/14/2016 Evergreen Telemetry RM-T-1 1600234 Radio Module 10/16/2016 Evergreen Telemetry RM-T-1 1700260 Radio Module 4/21/2017 Evergreen Telemetry RM-T-1 1700261 Radio Module 4/21/2017 Evergreen Telemetry PR-T-1 1400257 Temperature Probe (Air) 5/17/2017 Evergreen Telemetry PR-T-1 1600237 Temperature Probe (Air) 10/11/2016 Evergreen Telemetry PR-T-1 1600247 Temperature Probe (Air) 10/13/2016 Evergreen Telemetry PR-T-1 1600246 Temperature Probe (Air) 10/15/2016 Evergreen Telemetry PR-T-1 1600244 Temperature Probe (Air) 10/17/2016 Evergreen Telemetry PR-T-1 1700260 Temperature Probe (Air) 4/21/2017 Evergreen Telemetry PR-T-1 1700261 Temperature Probe (Air) 4/21/2017 Evergreen Telemetry PR-T-4 1400132 Temperature Probe (Insertion) 5/17/2017 Evergreen Telemetry S-H-3-5" 1500142 Humidity Sensor 5/18/2017 Evergreen Telemetry S-DP-125 1700112 Water Press. Sensing Module 3/2/2017 REMARKS: Not all equipment shown was used on this project. Project: Fort Collins Dental INSTRUMENT CALIBRATION REPORT (Continue) Page 2 of 12 Project: Fort Collins Dental Symbol Description Symbol Description A Airflow (L/S) NS Not Shown AF Air Foil NT No Information Tag ANA Access Not Available OD Outside Diameter BI Backward Incline RPM Revolution Per Minute CD Ceiling Diffuser SD Supply Diffuser CFM Airflow (Cubic Feet / Minute) SNKL Snorkel DD Direct Drive SP Static Pressure Des Design SPD Static Pressure Drop DWDI Double Width Double Inlet SR Supply Register EF Exhaust Fan SWSI Single Width Single Inlet EG Exhaust Grille T Temperature ( C ) ER Exhaust Register T Temperature ( F ) ESP External Static Pressure TSP Total Static Pressure FC Forward Curve VFD Variable Frequency Drive GPM Waterflow (Gallons / Minute) VS Variable Speed HC Heat Coil W Waterflow (L/S) HER Heat Exchanger HRC Heat Recovery Hz Hertz ID Inside Diameter In. WC Inches of Water Column NA Not Applicable NI Not Installed NIC Not In Contract NM Not Measurable NPT No Pressure Tap NR Not Readable REMARKS: Lawrence H. Finn & Associates, Inc. 55 S. Elm Ave, Suite 220 - Eaton, CO 80615 Phone (970) 454-5351 - Fax (970) 454-5391 ABBREVIATION REPORT Page 3 of 12 Roof Top Unit PROJECT: LOCATION: Ft Collins Dental Interior Remodel Ft Collins, CO DATE: CONTACT: AUTHOR: 12/21/2017 Keith Finn Joe Marshall Tested By: Keith Finn Date: 12/19/2017 SYSTEM/UNIT: RTU-3 Unit Data Unit Manufacturer Trane Unit Model Number YCH120F3RZA0E55 Unit Serial Number 171410241L RTU-3/Supply Fan Fan Type Air Foil Fan Size 18" OD Fan Class 1 Fan Arrangement SWSI Fan Discharge Plenum RTU-3/Filter Bank Filter Manufacturer Airguard Filter Type MERV 8 Filter Quantity 3/2 Filter Size 20x25x2/20x30x2 Starter Data RTU-3/Supply Fan Installed Thermal Internal Test Data Total CFM Design 4185 CFM Total CFM Actual 4132 CFM Outside Air CFM Design 654 CFM Outside Air CFM Actual 637 CFM RTU-3/Supply Fan Fan RPM Actual Medium High RPM Motor Volts 1 211 Volts Motor Volts 2 210 Volts Motor Volts 3 210 Volts Motor Amps 1 3.2 Amps Motor Amps 2 3.5 Amps Motor Amps 3 3.5 Amps Motor Data RTU-3/Supply Fan Motor Manufacturer Genteq Motor HP NS HP Motor RPM NS RPM Motor Rated Volts 208 Volts Motor Phase 3 Motor Hertz 60 Hz Motor FL Amps 8.3 Amps Sheave Data RTU-3/Supply Fan Motor Sheave Make Direct Drive Test Pressures OA Damper Pos Actual 20 % Unit External SP Actual 0.6 in. wc Roof Top Unit PROJECT: LOCATION: Ft Collins Dental Interior Remodel Ft Collins, CO DATE: CONTACT: AUTHOR: 12/21/2017 Keith Finn Joe Marshall Tested By: Keith Finn Date: 12/19/2017 SYSTEM/UNIT: RTU-3/Supply Test Pressures Final Filter SP In -0.20 in. w.c. Final Filter SP Out -0.30 in. w.c. Supply Fan SP In -0.45 in. w.c. Supply Fan SP Out 0.40 in. w.c. Cooling Coil SP In -0.30 in. w.c. Cooling Coil SP Out -0.45 in. w.c. Static Pressure Profile System/Unit Area Served Outlet Type Size LxW / D AK Factor Maximum Design Prelim Reading Maximum Final % Prelim Deviation % Final Deviation Outlet-01 105 CD-2 24x24 215 205 211 95 98 Outlet-02 106 CD-2 24x24 225 170 218 76 97 Outlet-03 110 CD-2 24x24 180 147 171 82 95 Outlet-04 106 CD-2 24x24 225 115 220 51 98 Outlet-05 106 CD-2 24x24 225 83 216 37 96 Outlet-06 120 CD-2 24x24 180 178 177 99 98 Outlet-07 119 CD-2 24x24 180 107 175 59 97 Outlet-08 118 CD-2 24x24 180 178 175 99 97 Outlet-09 117 CD-2 24x24 180 190 180 106 100 Outlet-10 104 CD-2 24x24 215 59 211 27 98 Outlet-11 114 CD-2 24x24 180 194 177 108 98 Outlet-12 101 CD-2 24x24 250 180 240 72 96 Outlet-13 102 CD-2 12x12 70 111 71 159 101 Outlet-14 103 CD-2 12x12 70 106 68 151 97 Outlet-15 101 CD-2 24x24 250 73 251 29 100 Outlet-16 100 CD-2 24x24 250 166 252 66 101 Outlet-17 100 CD-2 24x24 250 179 248 72 99 Outlet-18 100 CD-2 24x24 250 168 250 67 100 Outlet-19 115 CD-2 24x24 180 70 183 39 102 Outlet-20 100 CD-2 24x24 250 171 255 68 102 Outlet-21 116 CD-2 24x24 180 192 183 107 102 Totals: - - - 4185 3042 4132 73 99 RTU-3 Supply Outlet Summary L.H. Finn and Associates Final Report Page 5 of 12 Fan Unit PROJECT: LOCATION: Ft Collins Dental Interior Remodel Ft Collins, CO DATE: CONTACT: AUTHOR: 12/21/2017 Keith Finn Joe Marshall Tested By: Keith Finn Date: 12/18/2017 SYSTEM/UNIT: EF-1 Unit Data Fan Manufacturer Greenheck Fan Model Number SP-B110-QD Fan Serial Number 78006147-0018 Fan Type Forward Curve Fan Size 6" ID Fan Class 1 Fan Arrangement SWSI Fan Discharge Horizontal Starter Data Installed Thermal Internal Test Data Total CFM Design 70 CFM Total CFM Actual 119 CFM Fan RPM Actual Direct Drive RPM Motor Volts 1 123 Volts Motor Amps 1 1.0 Amps SP In Actual -0.1 in. wc SP Out Actual ANA in. wc Motor Data Motor Manufacturer Greenheck Motor RPM 950 RPM Motor Rated Volts 115 Volts Motor Phase 1 Motor Hertz 60 Hz Motor FL Amps 1.15 Amps Sheave Data Motor Sheave Make Direct Drive Tested By: Keith Finn Date: 12/18/2017 SYSTEM/UNIT: EF-2 Unit Data Fan Manufacturer Greenheck Fan Model Number SP-B110-QD Fan Serial Number 78006147-0025 Fan Type Forward Curve Fan Size 6" ID Fan Class 1 Fan Arrangement SWSI Fan Discharge Horizontal Starter Data Installed Thermal Internal Test Data Total CFM Design 70 CFM Total CFM Actual 104 CFM Fan RPM Actual Direct Drive RPM Fan Unit PROJECT: LOCATION: Ft Collins Dental Interior Remodel Ft Collins, CO DATE: CONTACT: AUTHOR: 12/21/2017 Keith Finn Joe Marshall Tested By: Keith Finn Date: 12/18/2017 SYSTEM/UNIT: EF-3 Unit Data Fan Manufacturer Greenheck Fan Model Number SP-A390C Fan Serial Number 15048257 Fan Type Forward Curve Fan Size 6" ID Fan Class 1 Fan Arrangement DWDI Fan Discharge Horizontal Starter Data Installed Thermal Internal Test Data Total CFM Design 300 CFM Total CFM Actual 367 CFM Fan RPM Actual Direct Drive RPM Motor Volts 1 122 Volts Motor Amps 1 1.3 Amps SP In Actual -0.2 in. wc SP Out Actual 0.15 in. wc Total SP Actual 0.35 in. wc Motor Data Motor Manufacturer McMillan Electric Motor HP 1/12 HP Motor RPM 1300 RPM Motor Rated Volts 115 Volts Motor Phase 1 Motor Hertz 60 Hz Motor FL Amps 1.4 Amps Sheave Data Motor Sheave Make Direct Drive Tested By: Keith Finn Date: 12/18/2017 SYSTEM/UNIT: EF-4 Unit Data Fan Manufacturer Greenheck Fan Model Number SP-B150-QD Fan Serial Number 78006147-0033 Fan Type Forward Curve Fan Size 6" ID Fan Class 1 Fan Arrangement SWSI Fan Discharge Horizontal Starter Data Installed Thermal Internal Test Data Total CFM Design 100 CFM Fan Unit PROJECT: LOCATION: Ft Collins Dental Interior Remodel Ft Collins, CO DATE: CONTACT: AUTHOR: 12/21/2017 Keith Finn Joe Marshall Tested By: Keith Finn Date: 12/19/2017 SYSTEM/UNIT: EF-5 Unit Data Fan Manufacturer Greenheck Fan Model Number SP-B150-QD Fan Serial Number 78006147-0021 Fan Type Forward Curve Fan Size 6" ID Fan Class 1 Fan Arrangement SWSI Fan Discharge Horizontal Starter Data Installed Thermal Internal Test Data Total CFM Design 100 CFM Total CFM Actual 106 CFM Fan RPM Actual Medium RPM Motor Volts 1 123 Volts Motor Amps 1 1.2 Amps SP In Actual -0.1 in. wc SP Out Actual 0.1 in. wc Total SP Actual 0.2 in. wc Motor Data Motor Manufacturer Greenheck Motor RPM 950 RPM Motor Rated Volts 115 Volts Motor Phase 1 Motor Hertz 60 Hz Motor FL Amps 1.8 Amps Sheave Data Motor Sheave Make Direct Drive L.H. Finn and Associates Final Report Page 8 of 12 Page 9 of 12 Page 10 of 12 Page 11 of 12 Page 12 of 12 Total CFM Actual 144 CFM Fan RPM Actual Direct Drive RPM Motor Volts 1 123 Volts Motor Amps 1 1.5 Amps SP In Actual -0.1 in. wc SP Out Actual ANA in. wc Motor Data Motor Manufacturer Greenheck Motor RPM 950 RPM Motor Rated Volts 115 Volts Motor Phase 1 Motor Hertz 60 Hz Motor FL Amps 1.8 Amps Sheave Data Motor Sheave Make Direct Drive L.H. Finn and Associates Final Report Page 7 of 12 Motor Volts 1 123 Volts Motor Amps 1 1.0 Amps SP In Actual -0.1 in. wc SP Out Actual ANA in. wc Motor Data Motor Manufacturer Greenheck Motor RPM 950 RPM Motor Rated Volts 115 Volts Motor Phase 1 Motor Hertz 60 Hz Motor FL Amps 1.15 Amps Sheave Data Motor Sheave Make Direct Drive L.H. Finn and Associates Final Report Page 6 of 12 RTU-3/Supply Fan Fan TSP Actual 0.85 in. wc L.H. Finn and Associates Final Report Page 4 of 12